Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Yamaha Tech
Yamaha Tech Originally the Yamaha XT600 Tech Forum, due to demand it now includes all Yamaha's technical / mechanical / repair / preparation questions.
Photo by George Guille, It's going to be a long 300km... Bolivian Amazon

I haven't been everywhere...
but it's on my list!


Photo by George Guille
It's going to be a long 300km...
Bolivian Amazon



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 12 Jan 2017
Registered Users
New on the HUBB
 
Join Date: Dec 2016
Posts: 17
1984 XT 600 ignition coil

My bike has been running, but it's very difficult to start, especially after it's warmed up. I'm trying to isolate issues, and my ignition coil seems to be bad. I'm reading way more resistance than spec. Does anyone have a good recommendation as to where I could find a replacement? The Yamaha part is running about $100 for the coil and plug boot, and that's a bit steep for my dirt-cheap budget bike, unless it's absolutely necessary.

I saw this on Ebay: Yamaha XT600 Ignition Coil 1984-1985 | eBay, but I'm a little suspicious, and it doesn't come with a spark plug boot. Any thoughts?
Reply With Quote
  #2  
Old 20 Jan 2017
Registered Users
Veteran HUBBer
 
Join Date: May 2013
Location: Wisconsin, USA
Posts: 827
The high tension wire just gets screwed on/of so you can used the one from your old coil , otherwise buy any NGK plug boot and wire , look up the resistor value in the XT manual and get a cap in that general range .
Reply With Quote
  #3  
Old 20 Jan 2017
Registered Users
New on the HUBB
 
Join Date: Jan 2017
Posts: 17
Also check the spark plug boot resistance. They should be replaced regularly.
Reply With Quote
  #4  
Old 20 Jan 2017
xtrock's Avatar
Registered Users
Veteran HUBBer
 
Join Date: May 2013
Location: Norway
Posts: 1,325
Quote:
Originally Posted by Beezageeza View Post
Also check the spark plug boot. They should be replaced regularly.
Okey thats new to me, please inform where you got this info from?
Reply With Quote
  #5  
Old 20 Jan 2017
Registered Users
New on the HUBB
 
Join Date: Jan 2017
Posts: 17
They have a resistor in the cap and sometimes this fails. I know this from personal experience trying to track down faults in old motorcycles over the years. Not sure if XT600's came from the factory with resistor caps but a PO could also have installed them. While I'm on it, best to replace the lead as well. the copper wires oxidize and corrode over time which also leads to poor spark. Make sure to use copper cable, not silicone. If it's difficult to find, try a marine store.

hope this helps!
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
XT600E Service Manual Download kentfallen Yamaha Tech 86 24 May 2023 09:10
XT600 - Model Codes kentfallen Yamaha Tech 27 3 Aug 2019 16:36
XT600 Parts Manuals (1990 - 2002) kentfallen Yamaha Tech 5 29 Jul 2016 11:13
ignition coil xt600e awolxt Yamaha Tech 15 3 Jun 2015 19:44
ignition coil question 1989 XT600 ajax Yamaha Tech 7 23 Sep 2013 10:12

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 19:31.