In regards to Dangerous Goods this site might be a good resource for dangerous goods training and general information relating to shipping etc.

Hopefully these images should help you. The first image is a scan of the DGR form used when I last shipped my motorcycle by air. The second image is that of DG stickers that were placed on my motorcycle.

The rules have changed fractionally in the last few years - the moto no longer needs stickers put on it if it is NOT crated. In other words, if it is obvious from looking at the shipment that the thing is a motorcycle (i.e. it is not concealed inside a box or crate), then you don't have to sticker it.

You really have to cross the T's and dot the I's on the DG forms. Even something as simple as using lowercase when you should use uppercase can cause problems. Although the air carriers are not allowed to complete the form for you, it is certainly reasonable to ask them to check the form to make sure you have filled it out properly and not made any errors.

All I ever did so far as preparing the motorcycle for shipment is concerned was to show up with less than 1/4 of a tank of gas, and disconnect and tape off the positive battery terminal. If you have a locking gas cap, make sure you leave the cap unlocked, so that the cargo handlers can check fuel tank contents if they wish to do so.

Michael

http://www.hostdub.com/albums/PanEur...R_labeling.jpg

http://www.hostdub.com/albums/PanEur...GR_Waybill.jpg

Just a follow-up to the post above: Below you will find the complete text of the IATA Dangerous Goods Regulations (DGR) that govern shipping motorcycles by air.

The moto itself is classified under UN 3166 as a 'Vehicle, Flammable Liquid Powered'. The Packing Instruction that gives the details of how the vehicle must be packed so that it is accepted for shipment is Packing Instruction 900.

The first image below shows the rules for UN 3166, the second illustration shows the rules for Packing Instruction 900. The two go hand in hand, in other words, if you comply with the packing instruction, you can submit your moto for shipment under UN 3166.

Some points that your cargo acceptance agent (the airline employee) may not be aware of:

1) If it is impossible (very unlikely) for the moto to be loaded in any position other than right-side up, then you don't have to drain all the fuel. Just run the tank down as low as possible, in no case have more than a quarter of a tank of fuel in it. On the other hand, if your moto is packed in a rectangular crate, and it is possible that some stupid person could put the crate in the airplane upside down, then you have to drain every drop of fuel from every nook and cranny of the moto - tank, carbs, etc.

2) If the battery is secured in its original location on the moto (where the manufacturer put it), and if all the panels are in place securing and protecting the battery, then you don't have to remove it, nor do you have to disconnect it.

3) The battery has to comply with the referenced packing instruction for batteries, however, just about every motorcycle or car battery made in the last 30 years will comply. That packing instruction says, more or less, that the battery must not melt like a chocolate bar and spill electrolyte all over if the ambient temperature gets up to 55 degrees C.

4) If it is obvious to an average person that the package you are shipping is, in fact, a motorcycle, then you do not have to put a sticker on it. If it is enclosed inside a box or crate - such that no-one could tell that there is a motorcycle inside the box or crate - then you need a class 9 (misc) DG sticker.

Hope this information is useful to you.

UN 3166 DGR Rules (Vehicles, Flammable Liquid Powered)
http://www.hostdub.com/albums/PanEur...DGR_Info_1.jpg

Packing Instruction 900 - how to pack a moto for air freight shipment
http://www.hostdub.com/albums/PanEur...DGR_Info_2.jpg

Example of when you don't have to drain the fuel totally, and don't need a sticker to identify the thing
It would be pretty hard to load this anyway except right side up, or fail to recognize that it is a motorcycle.
http://www.hostdub.com/albums/PanEur...n_can6_001.jpg