Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Yamaha Tech
Yamaha Tech Originally the Yamaha XT600 Tech Forum, due to demand it now includes all Yamaha's technical / mechanical / repair / preparation questions.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 18 Nov 2004
Registered Users
HUBB regular
 
Join Date: Mar 2003
Location: Vännäs, Sweden
Posts: 66
The death of all electrics...

Hi,

During a 7000km cross-Europe run, all the electrics on my 1VJ died. The flashers and signal is very faint. The headlight and taillight has a very low or no light at all.
The engine will start when I have the battery connected, but not without it.

Is it a faulty regulator?

It should start without battery, no?

Regards, RtS
__________________
Rikard the Swede
Reply With Quote
  #2  
Old 18 Nov 2004
Registered Users
Veteran HUBBer
 
Join Date: Nov 2002
Location: Surrey, UK
Posts: 183
Hi Rikard,

I am not very technical, but perhaps a couple of my thoughts will help get your answer - I don't mind commenting and getting shot down!

I think it is only the older bikes fitted with a magneto that will start without a battery fitted (ignoring the offered battery elimination kits you see on Ebay, etc...). Our coil system requires a battery. I think I would look to the alternator not supplying sufficient charge first. The Clymer Manual has the testing method to be followed - do you have a manual?

My gut feel is that the regulator would give you a more concrete problem if it was at fault (i.e. the bike would just not start). Fyi, there is no testing procedure noted for the regulator.

Hope you get to the bottom of your problem.

Ciao, Geoff
Reply With Quote
  #3  
Old 18 Nov 2004
Steve Pickford's Avatar
Contributing Member
Veteran HUBBer
 
Join Date: Jul 2003
Location: Oxford, UK
Posts: 994
If your bike has a kickstart & is equipped with a CDI ignition, it should start without a battery.

You should have three wires of the same colour coming out of the stator plate. Using a multimeter, check the resistance of all wires in pairs, should take three readings. Resistancer specs should be in the manual. If out of spec, check the stator for a burnt out coil(s). If burnt out, this would explain what sounds like poor charging.

It may be cheaper to get the stator rewound than buy a new one (that's the case in the UK anyway).

While you have the multimeter out, check the resistance of the two wires keading from the ingition pick, should be located on or near the stator plate - incorrect resistance here will lead to starting problems. Replace as necessary.
__________________
My photos: www.possu.smugmug.com
Reply With Quote
  #4  
Old 18 Nov 2004
Gold Member
Veteran HUBBer
 
Join Date: Apr 2000
Location: Samaipata / Bolivia
Posts: 888
hi,

please tell us what is/or was wrong with your 1VJ.

because I am also riding a 1VJ (now at 246.000km) and have the same electrical fault at the moment.

But as my alternator is newly overhauled and my battery is dead, I assume it is the voltage regulator. I dont carry a voltage meter.

But no problem riding the bike (kickstarter only), who needs lights in Africa.

Will check it out in a few weeks in Namibia.

Thanks from Lusaka Zambia

Mika

------------------
Reply With Quote
  #5  
Old 18 Nov 2004
Registered Users
Veteran HUBBer
 
Join Date: Jan 2001
Location: Stockholm
Posts: 651
Check the simple things first:
1. Is the fuse firmly in place? Just move it a bit in it's holder with the contact switched on, see what happens.
2. All earthing connections tightly done up?
3. Condition of the battery, measure voltage after 1 hour of standstill, look into the filling holes, any white residue, bent plates?

Succes!
Auke

__________________
Auke
http://aukemarieke.blogspot.com
Reply With Quote
  #6  
Old 18 Nov 2004
Registered Users
Veteran HUBBer
 
Join Date: Feb 2004
Location: Toulouse, France
Posts: 216
I think the magneto type is very old, otherwise now mostly used on small piston airplane engines, improved version of course..but very usefull in some cases to keep altitude..
Modern bikes have battery type ignition "TCI"; they won't run or start with a broken battery!
I guess Rikards bike is a one VJ the 1VJ as all 600 ténéré's have a "CDI" type ignition, which means; condenser DISCHARGE ignition.
It uses much less voltage than a TCI ignition..and it is known to be less durable than these others.
Personally..I've never ever had one only CDI
broken, and consider it very simple to bring a little spare CDI box instead of a big heavy spare battery and acid..

The regulator could be faulty, often this goes together with stator;
stator broken=regulator deteriorated

Or it could simply be a shortcut in your battery..try another!

Good luck in finding the problem (I'm sure it's a small one).

Regards,

Mattias the Swede/French
Reply With Quote
  #7  
Old 19 Nov 2004
Registered Users
Veteran HUBBer
 
Join Date: Aug 2001
Location: sunny England
Posts: 790
"the death of all electrics"

wasn't that an Imgmar Bergman movie with Max V Sydow?

sorry, i'm not helping, am i?



------------------
dave
__________________
dave
Reply With Quote
  #8  
Old 21 Nov 2004
Registered Users
HUBB regular
 
Join Date: Mar 2003
Location: Vännäs, Sweden
Posts: 66
Everything helps!

I´m tinkering...

Will report soon...
__________________
Rikard the Swede
Reply With Quote
  #9  
Old 22 Nov 2004
KlausXT600's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Sep 2000
Location: Hamburg, Germany
Posts: 295
hi rikard,
as far as i remember you put a 3tb engine in your bike, isn't it?
and didn't you change the ignition system as well?
if so, it would be an important information to those who try to help you...

good luck
klaus
xt600.de / tech. dep.
Reply With Quote
  #10  
Old 5 Dec 2004
Registered Users
HUBB regular
 
Join Date: Mar 2003
Location: Vännäs, Sweden
Posts: 66
Hi, Klaus

The 3TB engine went into my girlfriends 1VJ, it runs perfectly!

My 1VJ is still a 1VJ...
(you can never have enough Ténérés...)

Regards / R
__________________
Rikard the Swede
Reply With Quote
  #11  
Old 11 Dec 2004
Gold Member
Veteran HUBBer
 
Join Date: Apr 2000
Location: Samaipata / Bolivia
Posts: 888
hello xt freaks and travellers,

so, we made to Windhoek - just using the kickstarter on my bike.

here I bought a new battery and put in a new (better and bigger) voltage regulator and new light bulbs.

but now the problem started.

first there must be a loose connection somewhere, because sometime no electrical parts are works, and I cant find it.

second, it seems that the alternator does not charge the battery - only 12,3V when the engine is running. maybe I ruined it again, riding 10.000kms with a bad voltage regulator and a broken battery.

on monday I will have an expert having a look at the bike ...

wish me luck

any suggestions ?

mika from Windhoek Namibia

------------------
Reply With Quote
  #12  
Old 12 Dec 2004
Registered Users
HUBB regular
 
Join Date: Mar 2003
Location: Vännäs, Sweden
Posts: 66
Hi,

Maybe I´ll just buy another 3TB engine and do it all over again...

Sigh...
__________________
Rikard the Swede
Reply With Quote
  #13  
Old 12 Dec 2004
Registered Users
Veteran HUBBer
 
Join Date: Feb 2004
Location: Toulouse, France
Posts: 216
Hello Mika,

l don't mind answering, though on electrics l'm far not an expert, but very lets say beginer! l guess it is because l've had very few problems due to electrics,,,l must have been lucky,,!
Anyhow:
A dead battery/
B old battery that can't be recharged/
C dirty short cutted battery

A,B and C will result in:
Regulator trying constantly/desperately to charge battery until its normal voltage

But if battery can't hold the power it is receiving, it'll be like pooring water thru a hole instead of pooring it in a bottle for later drinking: lot of water to pump !

So regulator will fry trying to charge battery, cause battery absorbs nothing: regulator will overheat being on max all time,

lts not due to nothing that you have to fit a condenser to eliminate the battery on a
bike, and a condenser will last much longer than a battery !
l think a good idea is to have both!

l guess that if regulator is blocked, then stator will damage, not sure though!
Have you mesured the resistance of the charge coils?

Did you buy the right regulator?

No sulfate on battery main contacts surface,,,?
Screw them tight also

WD40 on most contacts!

ALSO, check resistance of these parts:
lgnition coil
lgnition captor coil

What if it was the Neiman having bad contact inside, WD 40 thru the little hole under handlbar front on neiman !

Let me know if you need any instructions for controls,


Matt
3AJ
Reply With Quote
  #14  
Old 15 Dec 2004
Gold Member
Veteran HUBBer
 
Join Date: Apr 2000
Location: Samaipata / Bolivia
Posts: 888
Hi all,

thank you for the answer. But what is a Neiman ?

Ok. Yesterday and today I had to sort out the electrics - I found many loose connetions, broken bulbs, a broken neutral switch and two burned relays. The alternator is not charging 100 % anymore, but it is charging the battery (13.1 V). Yeah, riding with a broken voltage regulator is no good.

It was a difficult job for me, but I had help from a very expierenced mc mechanic. Than it was even more difficult to find the relays, finaly I got two used relays from a TW200 for a high price.

So, after I put the new battery in and the new voltage regulator (www.kedo.de - they know the business with xt parts) and also the the two relays (one is for the starter motor and the other one for the headlight, I think), put new bulbs, some new plugs and wires and cleaned it all - it works again !!!

so good to use the electric starter again, I think the last time was in mosambique a few month ago. and even better all turning lights, break lights, the head light and even the speedo lights are working. only the neutral light is on all the time, because the switch is gone.

the bike (a 1VJ) has now 248.000km on some of the worst roads in the world, and it is ready for the way up West Africa to Europe.

Thanks again for the answers and advises

mika

------------------
Reply With Quote
  #15  
Old 18 Aug 2005
Registered Users
HUBB regular
 
Join Date: Mar 2003
Location: Vännäs, Sweden
Posts: 66
Hello everyone!

1000 thanx for all inputs, after a couple of hours messing about measuring and tinkering my mum came over to tell me that dinner was ready.

She stood there and looked at me go for a while and then she said "maybe it´s the lightbulb that´s broken?"

I snorde something and thought that I could check them just to be kind to her.

The front light broken, both filaments,
The park light broken,
The front left flasher broken,
The front right flasher broken,
The rear right flasher broken,
The left rear light broken,
The right rear light broken,
The left brakelight broken,
The right brakelight broken,

The battery eventually was of a B- quality and has probably shorted out and then the generator has burned all my lights.

New battery and new bulbs = A-ok!

Tried to start it without a battery, it works but DO NOT turn the lights on they burn out right away.

Can running without a battery damage the bike´s electrics?

Regards / Rikard
__________________
Rikard the Swede
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 23:20.