Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Yamaha Tech
Yamaha Tech Originally the Yamaha XT600 Tech Forum, due to demand it now includes all Yamaha's technical / mechanical / repair / preparation questions.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 30 Nov 2010
Registered Users
HUBB regular
 
Join Date: May 2010
Location: Cornwall
Posts: 38
3aj prep tips

Hi all, I own a '89 3aj, 25000 miles on the clock and it's a well looked after bike. I'm planing a trip UK to India and my question is, should I look at the engine, or should I take it that it will still have plenty of life left in it?
Also if anyone could give me any ideas of things I should be checking on the bike (faults etc). I will be replacing brake pads, battery closer to the time, and if anyone has any prep tips for the 3aj
Many thanks
Reply With Quote
  #2  
Old 30 Nov 2010
Registered Users
Veteran HUBBer
 
Join Date: Dec 2008
Location: Denmark
Posts: 1,417
My dj02 has over 80.000km on it, and i use it from everything from dayly commute, to enduro-ish races, and everything in between. Its still going strong, and uses no oil.

I would probably replace wheelbearings, and go over all other "external" bearings. (lube or replace)

Then all the usual stuff, change oil and filter, new tubes and tyres and so on.

Do it all a couple of weeks before you're trip, so you have time to "test" the bike afterwards.
Reply With Quote
  #3  
Old 1 Dec 2010
Registered Users
Veteran HUBBer
 
Join Date: Aug 2005
Location: Calgary AB
Posts: 1,032
Rear shock. Somehow the designers missed the calculation for full travel clearance and the exhaust touches the rear caliper bracket when it bottoms out. We went through 3 of these brackets. I'd make a guard for it.
__________________
Tacos Tyring Travels.com
Reply With Quote
  #4  
Old 2 Dec 2010
Registered Users
Veteran HUBBer
 
Join Date: Oct 2009
Location: Wiltshire, UK
Posts: 118
Well looked after 3AJ

Quote:
Originally Posted by fugitive View Post
Hi all, I own a '89 3aj, 25000 miles on the clock and it's a well looked after bike.
Is it your 25k or 4 previous owners? For a trip of that length I would personally at least put in new clutch plates, and might even consider pulling it right down to check the state of the gearbox pinions: a mate bought a one owner XT from a friend with similar mileage and had to replace 4th and 5th ratios - it had been geared up for economy on a long trip and driven hard at low revs. By comparison, my 40,000 km, 4 owner imported 1VJ is still sweet (though I'd definitely take it right down before a proper overland trip longer than 3 or 4 weeks.) I'll be giving it a new clutch at least before Morocco next May. I'd fit new wheel bearings when you do the tyres, chain and sprockets, as they're cheap and easy to do. Have a really good look at the fuel lines: the new additives in UK petrol seemsto be disagreeing with some old pipes - my Guzzi sprang a scary leak in Spain last year and the newish hoses were effectively disintegrating!
Reply With Quote
  #5  
Old 4 Dec 2010
Registered Users
New on the HUBB
 
Join Date: Dec 2010
Location: brighton
Posts: 5
Quote:
Originally Posted by guzzibob View Post
Is it your 25k or 4 previous owners? For a trip of that length I would personally at least put in new clutch plates, and might even consider pulling it right down to check the state of the gearbox pinions: a mate bought a one owner XT from a friend with similar mileage and had to replace 4th and 5th ratios - it had been geared up for economy on a long trip and driven hard at low revs. By comparison, my 40,000 km, 4 owner imported 1VJ is still sweet (though I'd definitely take it right down before a proper overland trip longer than 3 or 4 weeks.) I'll be giving it a new clutch at least before Morocco next May. I'd fit new wheel bearings when you do the tyres, chain and sprockets, as they're cheap and easy to do. Have a really good look at the fuel lines: the new additives in UK petrol seemsto be disagreeing with some old pipes - my Guzzi sprang a scary leak in Spain last year and the newish hoses were effectively disintegrating!

yes the gearboxes do go after a while
you prob have about another 10.000 miles on ur gearbox but if ur doing a long multi country trip replace the engine with a xt600'e' engine which is much stronger and less likely to let you down

i too have a 3aj and about the same miles but mine locked in 5th gear and now well its shagged im rebuilding my 3aj engine with 2003 xt600e internals and got a 1993 xt600'e' in it at the moment well once buttoned up and moted itll be back on the road oh how i miss it
Reply With Quote
  #6  
Old 6 Dec 2010
Registered Users
HUBB regular
 
Join Date: May 2010
Location: Cornwall
Posts: 38
Thanks everyone

Quote:
Originally Posted by tmotten View Post
Rear shock. Somehow the designers missed the calculation for full travel clearance and the exhaust touches the rear caliper bracket when it bottoms out. We went through 3 of these brackets. I'd make a guard for it.
This is my first try at multi quotes!!!!
Have made a hole in the exhaust already from it bottoming out on the caliper, i have adjusted it to it's hardest setting which is alot better.

Quote:
Originally Posted by guzzibob View Post
Is it your 25k or 4 previous owners? For a trip of that length I would personally at least put in new clutch plates, and might even consider pulling it right down to check the state of the gearbox pinions: a mate bought a one owner XT from a friend with similar mileage and had to replace 4th and 5th ratios - it had been geared up for economy on a long trip and driven hard at low revs. By comparison, my 40,000 km, 4 owner imported 1VJ is still sweet (though I'd definitely take it right down before a proper overland trip longer than 3 or 4 weeks.) I'll be giving it a new clutch at least before Morocco next May. I'd fit new wheel bearings when you do the tyres, chain and sprockets, as they're cheap and easy to do. Have a really good look at the fuel lines: the new additives in UK petrol seemsto be disagreeing with some old pipes - my Guzzi sprang a scary leak in Spain last year and the newish hoses were effectively disintegrating!
Quote:
Originally Posted by Jens Eskildsen View Post
My dj02 has over 80.000km on it, and i use it from everything from dayly commute, to enduro-ish races, and everything in between. Its still going strong, and uses no oil.

I would probably replace wheelbearings, and go over all other "external" bearings. (lube or replace)

Then all the usual stuff, change oil and filter, new tubes and tyres and so on.

Do it all a couple of weeks before you're trip, so you have time to "test" the bike afterwards.
Would replace bearings, clutch etc and give it a good service, it would also give me a good chance to learn my way around the bike.

Quote:
Originally Posted by biker-nut-1986 View Post
yes the gearboxes do go after a while
you prob have about another 10.000 miles on ur gearbox but if ur doing a long multi country trip replace the engine with a xt600'e' engine which is much stronger and less likely to let you down

i too have a 3aj and about the same miles but mine locked in 5th gear and now well its shagged im rebuilding my 3aj engine with 2003 xt600e internals and got a 1993 xt600'e' in it at the moment well once buttoned up and moted itll be back on the road oh how i miss it
I did think the 3aj was abit more bullet proof, I was aware of possible gearbox issues. So a strip down or a shorter trip, at least I have 2 years to decide, or do I sell a 3aj in very good condition and buy a different bike to travel on?
Reply With Quote
  #7  
Old 7 Dec 2010
Registered Users
Veteran HUBBer
 
Join Date: Oct 2009
Location: Wiltshire, UK
Posts: 118
Don't be too put off by all the horror stories - yes they wear out, but so do all these bikes after 20 or so years (and whatever you do, don't fall for the BMW hype that they are any different!!)
FWIW, if you're planning a big trip, I'd say take the XT. Get yourself a manual, some spanners and a gasket set, then tear it down to check out the wear, replacing worn bits as necessary. Then you'll be heading out on a bike that you are confident in, and will know how to fix if it does have a problem. If it's a shorter trip, just do the basics and go for it!! Good luck!
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Airhead prep chiefrider BMW Tech 14 24 Jul 2007 02:37
F650 Prep - help please twowheels03 BMW Tech 10 1 Feb 2007 17:34
prep an SV650 for Mexico? jtherkel Which Bike? 9 20 Oct 2004 02:38
XR600 prep Cugel Honda Tech 2 7 Apr 2004 18:46
Prep for 650 dakar in sahara peter bookey BMW Tech 6 17 Apr 2003 22:38

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 18:36.