 1Likes
 |
|
19 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Dec 2009
Location: Birmingham, UK
Posts: 126
|
|
|
Poor starting when not started for over a week.
My XT600E 4PT starts first push of the button from cold, if it has been started within the past few days. But leave it a week or more, and it's touch and go whether the bike will fire first, or whether the battery will run out of juice first, and getting it started often requires jump leads and more than 30 seconds on the starter button.
Any ideas what could be causing it, and if anything can be done to fix it?
So far I have put it down to fuel evaporation and/or degradation within the carb bowls, and the bike can't start until fresh fuel has been pulled through, but this is a guess.
|
19 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Apr 2003
Location: Manchester UK
Posts: 235
|
|
|
The most likely cause is a sub optimal battery. The motor etc will likely be tighter etc if it's stood for a while (including fuel evaportaion etc and all the other elements.) The load placed on the battery (remember they are not deep cycle batteries) will cause a voltage drop when starting. If you can measure this and see with a multimeter the voltage must not drop below 10v when cranking the starter motor over. Also note, running at a lower voltage can cause the starter motor to draw more amps to compensate (this becomes a vicious circle leading to weak spark etc as a by-symptom). This can severely shorten the starter motor life.
|
19 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Dec 2008
Location: Denmark
Posts: 1,417
|
|
|
He said it still takes 30secs with jump leads....
You need to fix/check all the obvious things, even if its just to rule them out:
Fresh sparkplug (and verify good strong spark)
Clean carb and jets
Fresh (or cleaned) airfilter
Check/adjust valves
Check battery voltage, while idling, reving, and under load (turn lights on without starting the bike voltage should still be over 12v)
Then you can do some real troubleshooting.
As a temporary fix, try to turn the fuel of a couple 100 meters before you get home. See if it helps.
Good luck.
|
19 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Apr 2003
Location: Manchester UK
Posts: 235
|
|
Quote:
Originally Posted by Jens Eskildsen
He said it still takes 30secs with jump leads.....
|
Absolutely. This does not detract from a low battery scenario. It adds to it. Notwithstanding any engine that has stood for a long time is generally harder to start.
Quote:
Originally Posted by Jens Eskildsen
You need to fix/check all the obvious things, even if its just to rule them out:
Fresh sparkplug (and verify good strong spark)
Clean carb and jets
Fresh (or cleaned) airfilter
Check/adjust valves
Check battery voltage, while idling, reving, and under load (turn lights on without starting the bike voltage should still be over 12v)
Then you can do some real troubleshooting.
As a temporary fix, try to turn the fuel of a couple 100 meters before you get home. See if it helps.
Good luck.
|
The above would not necessarily be symptomatic of a hard start after a lengthy period of being parked up, but would if it's a problem of hard starting from cold which is not the case. Also I dont believe cleaning the carbs will solve the issue even if it is a maintenance task as all of the above points are. However, potential airlocks in the fuel hose and sticky float valves may well be symptomatic. I'm still sticking with the battery as a first port of call. It's also the easiest to check tbh.
|
19 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: May 2008
Location: Mid Wales
Posts: 100
|
|
|
Sulking after being left.
My 3AJ Tenere is similar. If I drain some fuel through the bottom of the carb first it starts fine, but the drain screw is starting to round off.
|
19 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Dec 2009
Location: Birmingham, UK
Posts: 126
|
|
|
Thanks folks, keep the suggestions coming.
I don't think the battery is suspect, it will turn the engine over for 30 seconds or more and sounds like a good strong turn of the starter, but sometimes that's not enough for the bike to fire, and then I have to get the jump leads out. I will test it though because as you say it's easy to rule out.
I could understand low voltage effecting spark on a bike where the battery feeds the coils, but is the XT not a CDI magneto type system anyway, ie: it doesn't actually need a battery to start? One of my engine covers has a blank plate where a kickstart obviously used to be on older models.
Fresh sparkplug (and verify good strong spark) - Done
Clean carb and jets - Never had them out, but have run Redex through
Fresh (or cleaned) airfilter - Done
Check/adjust valves - No, I've never checked them. What's the service interval for them?
Will also try the fuel draining trick, if that works then it's definitely a fuel evaporation/degradation issue. Like I said, if it's been started in the last 3 or 4 days it fires first time, which tells me it's something related to the amount of time it's been standing.
|
20 Oct 2011
|
|
R.I.P. 25 November 2021
Veteran HUBBer
|
|
Join Date: Feb 2010
Posts: 688
|
|
|
Jens suggestion was good, good practice in any motor in fact. Turn off the gas taps & let the carbs run dry, and splash out on a new plug.
Mezo.
|
20 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Mar 2007
Location: UK
Posts: 4,343
|
|
Quote:
Originally Posted by Mezo
Jens suggestion was good, good practice in any motor in fact. Turn off the gas taps & let the carbs run dry, and splash out on a new plug.
Mezo.
|
+1 for running off some fuel when coming to a halt for any length of time. It's not needed for stopping for a cup of tea, but I have developed my own procedure to shut off the fuel tap before stopping the engine at the end of a run. I have found that this helps for cold starting after the bike has been standing for a while. Trying to explain this to myself but I don't know why it should help - one guess is that the float might stick in the up position so starving the engine of fuel until it drops. Who knows?
Also, I don't necessarily run the engine completely dry - I usually just run off some amount of fuel so that the float is not at its' highest position while standing for long periods.
Hope this helps
__________________
Dave
|
21 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Apr 2005
Location: Oxford UK
Posts: 2,104
|
|
|
Another vote for the fuel draining fix. My XR600 is exactly the same - leave it for a week and it can take hours to get it going (kickstart only). Drain about half a float chambers worth of fuel out first and it's first or second kick.
|
22 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Jun 2008
Location: yorkshire england
Posts: 201
|
|
|
hi guys if my 1985 43f xt600 is left for more than a week i drain the carbs , it starts up strieght away if i dont drain the carbs it can be a 20-25 kick job. modern fuel must go off in small amounts ie the carb bowl ? . zigzag
|
23 Oct 2011
|
|
Contributing Member
HUBB regular
|
|
Join Date: Mar 2008
Location: Bathgate, Scotland
Posts: 44
|
|
|
Flush out your fuel tank
I had a similar problem on my 3AJ. What seemed to resolve it was taking out the fuel tank and flushing it out.
If I left the bike for any length of time it seemes that water rather than fuel settled at the bottom of it, so that was being drawn through the carbs and the bike wouldn't start.
Euan
|
23 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Dec 2009
Location: Birmingham, UK
Posts: 126
|
|
|
Interesting theory about the water in the fuel tank. The bike has been run out of fuel completely recently though (that's not part of the problem, it was like it before), would that not have left the bottom to the tank dry?
|
23 Oct 2011
|
|
Registered Users
HUBB regular
|
|
Join Date: Dec 2005
Location: Simonstone, Lancashire, England
Posts: 63
|
|
|
I don't have an answer but your not alone, my 3YF 660xtz has been the same since I bougth it 4 years ago, leave it a day and starts on the button, two days and it takes 10 seconds, 3 days and 20 seconds and a week its 30 seconds, after about one or two months it takes over a minute, thankfully the previous owner put a new battery on before I bought it and it turns over forever:-)
I guessed it has something to do with the vacuum fuel pump needing priming , but I might try the turning off the supply before stoping and see if that helps
I just need to use it more :-)
__________________
Take care out there
Brian
Britch's Holidays Dreaming of the BIG one :-)
|
24 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Mar 2007
Location: UK
Posts: 4,343
|
|
|
Shut off the fuel tap
Hmmmm, seems that the theory and practice is good even if no one has a full explanation. It has certainly been my practice for any single cyl bike that I have ever owned that has a fuel tap - so that will be any single with a carb. Funnily enough I haven't tended to find it necessary for the inline 4s' that I have owned.
And I still don't know why it helps 
__________________
Dave
|
30 Oct 2011
|
|
Registered Users
Veteran HUBBer
|
|
Join Date: Dec 2009
Location: Birmingham, UK
Posts: 126
|
|
|
Well thanks folks. About three weeks since the bike was started, drained some fuel from the bowl, opened the tap, and it fired second turn of the starter. When it came to put the bike away I just let it tick over on the driveway with the fuel tap closed. By the time I'd got my helmet and gear off and put away, the bike had run out of fuel and cut out.
Hopefully it'll fire first time the next outing.
Still not an explanation of what the problem is but at least it's a work around.
|
|
Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...
2020 Edition of Chris Scott's Adventure Motorcycling Handbook.
"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)
Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.
Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.
Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!
What others say about HU...
"This site is the BIBLE for international bike travelers." Greg, Australia
"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK
"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia
"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA
"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada
"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa
"This is the answer to all my questions." Haydn, Australia
"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany
Lots more comments here!
Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook
"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.
Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!
New to Horizons Unlimited?
New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!
Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.
Read more about Grant & Susan's story
Membership - help keep us going!
Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.
You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.
|
|
|
helps answer the question - Why Go? Inspirational stories by veteran travellers Greg Frazier (5 times RTW), Peter and Kay Forwood (193 countries), Tiffany Coates (Mongolia Mayhem) and Rene Cormier (University of Gravel Roads).
Get Ready! covers planning, paperwork, medical and many other topics! "Inspirational and Awesome!" See the trailer here!
What stuff do I need - riding gear, clothing, camping gear, first aid kit, tires, maps and GPS? What don't I need? How do I pack it all in? Lots of opinions from over 150 travellers!
break down language barriers, overcome culture shock, ship the bike and deal with breakdowns and emergencies."Just makes me want to pack up and go!" See the trailer here!
Grant demystifies the black art of Tire Changing and Repair to help you STAY on the road! "Very informative and practical." See the trailer here!
Ladies on the Loose! For the first time ever, a motorcycle travel DVD made for women, by women! These intrepid women share their tips to help you plan your own motorcycle adventure. They also answer the women-only questions, and entertain you with amazing tales from the road! Presented by Lois Pryce, veteran solo traveller through South America and Africa and author of 'Lois on the Loose', and 'Red Tape and White Knuckles.'
Cotton or synth sweat-wicking t-shirts with the cool Horizons Unlimited graphic on the front and a snappy slogan (changing every year) on the back.
Show your route on your panniers. Great conversation starter when you meet people on the road!
Motorcycle and travel books to inspire and inform you!
The definitive guide to planning your motorcycle adventure! This insanely ambitious 2-year project has produced an informative and entertaining 5-part, 18 hour video series. "The ultimate round the world rider's how-to!" MCN UK.
Linear Mode
