Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Yamaha Tech
Lights drain battery Lights drain battery
Register FAQ Calendar Search Today's Posts Mark Forums Read
Yamaha Tech Originally the Yamaha XT600 Tech Forum, due to demand it now includes all Yamaha's technical / mechanical / repair / preparation questions.
Photo by Ellen Delis, Lagunas Ojos del Campo, Antofalla, Catamarca

I haven't been everywhere...
but it's on my list!


Photo by Ellen Delis,
Lagunas Ojos del Campo,
Antofalla, Catamarca



Like Tree1Likes

Reply
Page 1 of 5 1 2345
 
LinkBack Thread Tools Display Modes
  #1  
Old 16 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Jan 2012
Location: North London
Posts: 102
Lights drain battery
Any clues where to look on an XT600E 3tb that is draining / killing the battery when the lights are on ? Getting nearly 14 V until the lights are on and then the reading starts sliding downwards.
The AA recovery man described it as the alternator breaking down under load ???

Cheers
Min
Last edited by theoneandonlymin; 16 Aug 2013 at 15:19. Reason: additional info
Reply With Quote
  #2  
Old 16 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Mar 2007
Location: UK
Posts: 4,343
" The AA recovery man described it as the alternator breaking down under load "

He might be right; there again, he might be wrong - most of these folks out on the road nowadays with the AA/RAC are quick to get you off the highway and less inclined to fix modern, complex vehicles on the side of the road.
Generally, they are even less keen when called out to a bike, even one with old school technology!

Anyway, for your current issue, you should explain if the engine is running when you check the symptoms; basically, provide as much relevant information as possible.

The state of charge/discharge of the battery depends on such factors.
__________________
Dave
Reply With Quote
  #3  
Old 16 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Dec 2008
Location: Denmark
Posts: 1,417
Its probably the regtifier going bad....
Reply With Quote
  #4  
Old 16 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Jan 2012
Location: North London
Posts: 102
Results just in.
Battery fully charged on trickle/load charger this morning. Didn't take voltage but it should have been 13.8v or higher.
24 miles later, no headlights being used 13.2 V

Tickover no lights :14.15 V
Headlight on : 13.2V which after a few minutes is down to 12.7V

Then I took it out twice , 2 miles commuting run 30mph 3rd gear to keep the revs up a bit;

No Lights : Start 13.42 V returned with 13.85 V

Lights : Start 13.85 V returned with 12.60 V

Same route same traffic same ....


Thanks
Min
Reply With Quote
  #5  
Old 16 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Mar 2007
Location: UK
Posts: 4,343
You still know more about this bike than anyone else
So,
Your tests indicate that the bike is charging when the lights are off but it is not charging when the electrical load is higher, with the headlight on.

As Jens says, maybe the RR is failing.

Answers nearly always generate more questions!

Do you have a wiring diagram for this bike?
How is the condition of the wiring loom?
Are all the earth/ground connections good?
Is the battery a known quantity - a good 'un?
Have you changed anything recently?
(An electrical fault might be the result of a particular single event or a gradual deterioration in the loom or a component).

Have a read through this thread for some ideas about fault finding:-
http://www.horizonsunlimited.com/hub...charging-67094
The beginning and the end are most relevant, unless your loom is as bad as the one discussed in that thread.

You need to be logical with mechanical problems and even more logical in faults of electrical circuits.
__________________
Dave
Reply With Quote
  #6  
Old 17 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Aug 2012
Location: Australia
Posts: 1,131
It is relatively simple to do some resistance readings on the stator to check that it is ok. After that suspect rectifier/regulator. Use your manual to find the readings you should get.

You don't have supper bright headlight globes do you? Nor driving lights?
Reply With Quote
  #7  
Old 17 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Sep 2012
Location: Middle USA
Posts: 349
Sounds like the regulator/rectifier is dying and cannot keep up with the load if the lights are on.

What is the charging voltage both with light off and light on, idle and higher speed. It should keep the voltage above 13.5 under load if working correctly and perhaps more.
Reply With Quote
  #8  
Old 17 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Jan 2012
Location: North London
Posts: 102
See above for the voltage readings. I will go through the Electrex fault finding found here....

http://www.electrosport.com/media/pd...ng-diagram.pdf

No big headlights, will whip the rack off and check RR earth etc under the tailpiece.

speak y'all Tuesday

Thanks
Min
Reply With Quote
  #9  
Old 17 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Mar 2007
Location: UK
Posts: 4,343
Quote:
Originally Posted by Walkabout View Post
even more logical in faults of electrical circuits.
Quote:
Originally Posted by theoneandonlymin View Post
It's hard to beat a flow chart for a dose of logic; nice find.
Enjoy!
__________________
Dave
Reply With Quote
  #10  
Old 18 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Jan 2012
Location: North London
Posts: 102
So I went to Page B after doing the START page and at the bottom of B where it says about the AC voltage out of the stator and three readings not being equal. Two of the readings were around the 70V level and one was 2V ! So what I am going to check next is the wiring closer to the stator to check for continuity to the three way block that goes to the RR.
Makes sense to me and is looking more like the stator according to the flow chart.

Min
Reply With Quote
  #11  
Old 18 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Sep 2012
Location: Middle USA
Posts: 349
Yep,if you lose one of the 3 phases, you are at 2/3's capacity. Good find. I hope you find a wire problem and not the actual stator...
Reply With Quote
  #12  
Old 20 Aug 2013
bacardi23's Avatar
Registered Users
Veteran HUBBer
  
Join Date: Sep 2007
Location: XXX<-Portugal->Azores->Santa Maria (island)
Posts: 1,544
Use a multimeter with continuity test to check your stator!

Disconnect behind the left seat cover and check all three pins coming from the stator have continuity between them all!

Next, check each pin with a good frame ground point! It can NOT have any continuity!

If these test are good, it's just the regulator/rectifier gone bad. IF not, you need a new stator or get yours rewound!

I had the exact same problem and it was actually both the stator and the reg/rectifier gone bad!


Vando
Reply With Quote
  #13  
Old 20 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Jan 2012
Location: North London
Posts: 102
No continuity with one of the wires either at the connector or bared wire down at the starter motor area . So a rotor is winging its way from Electrex . Now what are the top tips / necesary tools and gaskets for replacing it ?
Apart from a dry day !

Thanks again
Min
Reply With Quote
  #14  
Old 20 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Aug 2012
Location: Australia
Posts: 1,131
Quote:
Originally Posted by theoneandonlymin View Post
Now what are the top tips / necesary tools and gaskets for replacing it ?
Apart from a dry day !

Test the new stator before installation! It could be faulty when you get it and rather than find out after you have put it in, do test it first!!!

If you have not ordered any gaskets with the stator then get some silastic (RTV732 or equivalent) and use that in-conjunction with the old gaskets to ensure a seal.

A 'dry day' can be fabricated using a tent fly - rig it over the top of the bike.

Once you have everything back together ... test the electrical system to ensure that it is all working .. rectifier, regulator, battery ...
Reply With Quote
  #15  
Old 21 Aug 2013
Registered Users
Veteran HUBBer
  
Join Date: Mar 2007
Location: UK
Posts: 4,343
Quote:
Originally Posted by Walkabout View Post
S
Do you have a wiring diagram for this bike?
I guess I should have asked, also, do you have a workshop manual?

I've had the side cover off the generator of a TTR600 (it has the same engine, more or less) but I didn't change the stator.
What I do remember is:-
1. There is oil in there - I think I tipped the bike over on its' side to stop it running out, but I may have drained it (someone else can add to this point).
2. I definitely got a new paper gasket for that cover on the basis that they are one-use only and it is a PITA to put it all back together to then find that there is oil leaking/weeping.
__________________
Dave
Reply With Quote
Reply
Page 1 of 5 1 2345

« Previous Thread | Next Thread »

Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes
Linear Mode Linear Mode

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

Similar Threads
Thread Thread Starter Forum Replies Last Post
Motobatt Battery - Any good? kentfallen Yamaha Tech 14 10 Oct 2017 17:16
Electrical Equipment? adam402 Camping Equipment and all Clothing 14 13 Jun 2013 08:34
Need Battery Tiger 800 XC in Guanajuato John Hubbard Central America and Mexico 2 27 May 2013 13:12
Looking to buy a 12V 10-12AmpHour battery between Mancora & Lima (Peru) arooni SOUTH AMERICA 0 7 Oct 2012 03:23
Battery trickle charger.. bacardi23 Yamaha Tech 7 24 Dec 2011 22:37

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

Your ad could be here, on EVERY page of the HUBB, or the whole website, or as many as you like!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.



All times are GMT +1. The time now is 03:30.

Contact Us - Horizons Unlimited Motorcycle Travellers Website - Archive - Privacy Statement - Top