Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Yamaha Tech
Yamaha Tech Originally the Yamaha XT600 Tech Forum, due to demand it now includes all Yamaha's technical / mechanical / repair / preparation questions.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 4 Apr 2007
Registered Users
New on the HUBB
 
Join Date: Apr 2007
Location: UK
Posts: 5
Inconsistent tickover on 34L XT

Hi,
I'm currently heading along the North of the Niger from Niamey to Timbuktoo via Gao and Bourem; I've had a few ignition problems and have replaced the CDI on the bike twice and the coil once; occasionally it ticks over just fine, then 10 minutes later it will be surging and eventually will cut out. The bike has also started back-firing quite badly on the overrun. Does anybody have any ideas how to rectify this?
Cheers.
Reply With Quote
  #2  
Old 4 Apr 2007
Registered Users
HUBB regular
 
Join Date: Dec 2006
Location: Brum
Posts: 44
I would check the carb' if you are getting surging - partially blocked pilot jet, air leaks around inlet rubber/carb joint, poor seating of the float needle etc. Take the float bowl off and see if there's any dirt lying in the bottom which isn't good as it can subsequently block the pilot/needle jet holes.

is the choke coming off fully?

backfiring on the overrun is normally due to air leaks in the exhaust, especially at the cylinder head.

I'd look at these things before you go back to the ignition

good luck!
Reply With Quote
  #3  
Old 5 Apr 2007
Registered Users
Veteran HUBBer
 
Join Date: Mar 2007
Location: UK
Posts: 4,343
There are similar discussions in the threads here - suggest you take a look at those for more advice (same as I am doing right now!!) if you need it.

rickg,
are there any points to look for with the float bowl off, apart from muck lying in the bottom and does the bowl come off with no problems while the carbs are on the bike?

Also, how can I tell if the choke is working properly? e.g. returning to the fully in position.

Apologies for these basic questions, but I am very new to this engine.

Dave
__________________
Dave
Reply With Quote
  #4  
Old 5 Apr 2007
Registered Users
HUBB regular
 
Join Date: Dec 2006
Location: Brum
Posts: 44
Dave

Ok, it's been a while since I had my XT so this is from memory. There are at least 4 cross-head screws holding on the float bowl. They are tight and made of cheese. The inner screws are probably hidden by the secondary carb body. If you have a good cross-head screwdriver of exactly the right length you may be lucky enough to get them out but it's vital that you don't mess up the heads else it'll subsequently be very difficult to get them out, even with the carb' off the bike. You would probably be better off resigning yourself to taking the carb' off the bike and taking the opportunity to look over the carb' thoroughly, there's not much you can do or see with just the bowl off, though you may be able to remove the floats and then look at the float needle which shouldn't have signs of a groove around it - wear could alter the fuel level in the carb' or allow fuel to leak in and make the bike run rich

there ought to be drain screw facing outward on the base of the float bowl. It may be worth draining the bowl into a clean container and looking to see if any muck gets flushed out. If it does (and I assume you too have poor tickover?) the next thing is to check for any dirt in the pilot jet. The hole in this is tiny, so it doesn't take much to block it.

As long as the choke returns to the fully-in position it should be ok but there is I think a seat on the end which bungs-up the choke-circuit to cut off the fuel when running normally. Clearly this seal needs to work or it'll run rich at tick-over when hot.

The carb' is a complicated jobbie, it'd really be worth your while tracking down a manual from the 'net. I think there have beens some posts on this site in the past with places you can download.

cheers

rick
Reply With Quote
  #5  
Old 5 Apr 2007
Registered Users
Veteran HUBBer
 
Join Date: Mar 2007
Location: UK
Posts: 4,343
Rick,
You are a star; confirms my reservations about taking off the bowl while doing handstands! I've had that experience already just fiddling with the pilot jet adjustment screw.

This connects with my own thread about poor/difficult starting - an ongoing tale as of today - From memory, I think you have been contributing and helping me there as well.

The choke definitely does not return all the way in; there is about 20 mm of "bare metal" showing when the control knob is pushed in - any thoughts on that?

I do have a manual for a TTR and I have a feeling I will be stripping the carbs once I have seen a good spark!!!!! (Got to do one thing at a time - can't multi-task nowadays!!). I will try your drain suggestion first of course.

Toecutter,
Sorry for hogging your thread; I hope that these discussions on here are of some use to you as well.

Regards,

Dave
__________________
Dave
Reply With Quote
  #6  
Old 6 Apr 2007
Registered Users
HUBB regular
 
Join Date: Dec 2006
Location: Brum
Posts: 44
I'd say if the choke goes in until it won't go any further and doesn't pop out when you let go ther's nothing much wrong with it. There will be some 'spare' rod left even when fully in

Don't pull the carb' to bits until you are happy you have a decent spark.

You say you've been fiddling with the pilot screw too? Was that before or after you had problems.... :-)

Rick
Reply With Quote
  #7  
Old 9 Apr 2007
Registered Users
New on the HUBB
 
Join Date: Apr 2007
Location: UK
Posts: 5
Inconsistent tickover etc

Cheers for the quick reply Rick and Dave,
I checked the exhaust and inlet rubbers etc, and all was well. I've just ridden it hard through a lot of sand along the Niger and now it seems to be running just fine. Maybe just some sediment floating around in the bowl which has now come out in my multiple tumbles!
I'll strip the carbs when I have regained my energy, 'cause I'm sure it's just some crappy blackmarket fuel.
Thanks and good luck with yours Rick. The carbs are pretty easy to get off and on, especially if you soak the rubbers in hot water before putting them back in to soften them up a bit.
Bye for now,
Darryl.
Reply With Quote
  #8  
Old 11 Apr 2007
Registered Users
Veteran HUBBer
 
Join Date: Mar 2007
Location: UK
Posts: 4,343
Quick update............

.......for anyone interested!

Glad to hear that Darryl/Toecutter is sorted out; for myself, I still need to get the spark plug out to check the ignition (a whole story on my own thread!). I don't yet have the right spark plug spanner, which seems to be a tad specialist, to fit under the frame.

In the meantime, I have run quite a bit of fuel out of the drain screw on the float bowl and it is perfect - no muck showing at all. Thanks for the advice about the choke etc. All very useful as and when/if the carbs have to come off the bike. I certainly won't be doing that until the spark is assured though!!

As a point I could not get a pipe onto the drain of the bowl (no room for that against the oil tank) so I used a bit of tin/cooking foil as a makeshift funnel and ran the fuel off into a jamjar.

My fiddling with the pilot jet was after the poor starting appeared - pretty recent in fact and was based on other advice in my thread.

You can tell from the above that the bike still won't start; glad I am not on the Niger at the mo!!

Cheers,

Dave
__________________
Dave
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Help Please - 34L "popping" jim Yamaha Tech 4 2 Apr 2007 13:20
XT600Z 34L silencer question andylarkin Yamaha Tech 0 24 Mar 2007 14:43
3AJ tickover evans Yamaha Tech 1 21 Jun 2006 00:56

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 08:02.