Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Yamaha Tech
Yamaha Tech Originally the Yamaha XT600 Tech Forum, due to demand it now includes all Yamaha's technical / mechanical / repair / preparation questions.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 12 Nov 2008
BlackDogZulu's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Oct 2008
Location: West Wales, UK
Posts: 753
Hi, and first question ...

Hi all - new to the forum. I've recently bought a 1995 XT600E for commuting duties through winter, having owned two 350s and a 660R in the past (I just love XTs). Having read a lot on this forum, I am now seriously thinking about prepping it for a bit of serious touring. Just when you think you have your life in order ...

Anyway, a question. I've just done a full service as previous service records were non-existent and the bike is fairly tatty. On opening the air filter box, I found a quantity (about 20ml) of engine oil in the bottom, although the filter element was not contaminated. This has accumulated in the last 1000 miles, as I had a look in there when I bought it, and there was oil in there then, which I cleaned out. I would suspect worn rings, allowing cylinder pressure to blow oil out through the breather, but I'm open to any advice or ideas from someone with a better knowledge of these engines than I have.

Many thanks.

Rich
XT600E 1995
__________________
2006 XT660R daily ride, 1994 XT600E about to be reborn, Blog: http://goingfastgettingnowhere.blogspot.com/
Reply With Quote
  #2  
Old 12 Nov 2008
BlackDogZulu's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Oct 2008
Location: West Wales, UK
Posts: 753
Sorry, should have said it is a 3AJ motor.

(At least, it has "3AJ00" written on the LHS of the cylinder.)
__________________
2006 XT660R daily ride, 1994 XT600E about to be reborn, Blog: http://goingfastgettingnowhere.blogspot.com/
Reply With Quote
  #3  
Old 13 Nov 2008
Registered Users
HUBB regular
 
Join Date: Aug 2006
Location: UK
Posts: 45
The engine is designed so that the crankcase will breath into the airbox (as you know ofc). Therefore it is only natural that there should be oil collecting there, there is even a little drainage tube with a bung in the bottom to allow you to drain this without opening the airbox. Essentially, unless the amount of oil in the airbox is excessive (contaminateing the airfilter) then don't worry, all is as it should be. 20ml is fine.

By far the most common reason for excessive oil in the airbox is over filling the oil tank at oil change. Check this before worrying about other problems, especially if you have no other symptoms.
Reply With Quote
  #4  
Old 13 Nov 2008
Registered Users
HUBB regular
 
Join Date: Aug 2007
Location: Nice, France
Posts: 85
Its not usual though, at least in my experience - I've never seen a drop of oil in my airbox in 20 years running.

Lots of 'orrible black stuff, coating all surfaces including my 'didnt stay red for very long' K&N filter, but that seems like 'normal' crankcase breathing?
Reply With Quote
  #5  
Old 13 Nov 2008
BlackDogZulu's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Oct 2008
Location: West Wales, UK
Posts: 753
Thanks guys. I hadn't spotted the drain hole, so I will look for that and see what happens. The oil in there was clean, i.e. used engine oil colour, not black horrible stuff, but the quantity was more than I was expecting to see. Most engines I have worked on are a little dirty in there, but to see a pool of oil in the bottom was a bit of a surprise.

I've been looking back through old posts on the forum, and there was one guy who was getting the same thing and it turned out to be overfilling with oil at a change. I have been checking the oil level as per the manual (run for 10 mins, stop engine, leave for 5 mins, check with dipstick unscrewed and bike vertical) and have kept the level up to the max mark. I check every week and have occasionally topped it up. I wouldn't expect it to be overfilled this way, but now I am not so sure.

And another odd thing ...

The manual gives the quantity of oil for a filter change (no dismantling) as - I think - 2.8 litres. I bought a 4l can of oil and used all of it before the oil came up to the right level as described above. So I have put in way more than recommended (yes, I bled the filter housing) and this is making me wonder what I am doing wrong. Have I got the level-check wrong (which would account for both the issues above)? This was after I noticed the oil in the air filter, by the way, so not connected.

I'm not using the bike this week for other reasons, so I will leave it to the weekend and look again. Perhaps drain the oil and start again.

Thanks for the help.

Rich
__________________
2006 XT660R daily ride, 1994 XT600E about to be reborn, Blog: http://goingfastgettingnowhere.blogspot.com/
Reply With Quote
  #6  
Old 13 Nov 2008
Registered Users
HUBB regular
 
Join Date: Mar 2007
Location: london
Posts: 69
Hello and welcome Rich.

it's most probably caused by too much oil in your engine.
I had the same inconvenient on my TTR600 (3AJ).

When I had an MOT done, about an year ago, also got oil / filter changed, by a garage, and they got it wrong... by putting too much oil in.

Not a major problem i think, but the engine gets all dirty by spluttering it out (in the air box too).

In my experience, i noticed that there are not many people around (in the mechanic places) who know exactly how much oil goes in there... apparently it's a bit tricky.
It's far better to do oil / filter change by yourself, as it's easy to get it right, with a bit of patience.

Put the oil in (not too much.. around 3 lt. i'd say)... go for a 10 mins spin... check the oil level again, top it up... go for another spin... check it again, top it up... and keep doing so till you reach just below the top mark (and doesn't go down).
If you go touring... remember to always have some oil for top ups with you (especially in hot weather).

Doing the oil changes by yourself also avoids the danger of the mec ruining the thread on one of the oil filter cover's bolt (top right one, i think), which is a very common problem on these engines.

Lots of guys on this forum will tell you that they would never let a mechanic do the oil change on their XTs, just because of this.

Good luck
diego
Reply With Quote
  #7  
Old 13 Nov 2008
BlackDogZulu's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Oct 2008
Location: West Wales, UK
Posts: 753
Hi Diego

Many thanks for the info. It certainly looks like I have too much oil in there. I've only done about 50 miles since I serviced it, so I will keep it off the road until the weekend, half drain it, and then do what you suggested. If it's blown half a litre into the airbox by that time, I'll know why!

Cheers

Rich
__________________
2006 XT660R daily ride, 1994 XT600E about to be reborn, Blog: http://goingfastgettingnowhere.blogspot.com/
Reply With Quote
  #8  
Old 13 Nov 2008
bacardi23's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Sep 2007
Location: XXX<-Portugal->Azores->Santa Maria (island)
Posts: 1,544
It won't blow half a liter in to the airbox but it will surely drop through a small tube that you should have between the engine and the rubber boot of the rear shock while you're actually riding...

When you stop the bike be sure to set it on a clean place where you can see if there are any gravitational oil drops on the floor close to where I just mentioned.. (they might not drop instantly)..


Have fun!

Vando
Reply With Quote
  #9  
Old 13 Nov 2008
BlackDogZulu's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Oct 2008
Location: West Wales, UK
Posts: 753
Thanks Vando

I can safely say the bike has never dropped any oil since I have had it. It's always parked in the same place, and I am sure my wife would have noticed something and pointed it out - gently and reasonably - if it had.

Like: "What's all that oil doing on my drive, you idiot?"
__________________
2006 XT660R daily ride, 1994 XT600E about to be reborn, Blog: http://goingfastgettingnowhere.blogspot.com/
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
To buy or not to buy...that is the question. orrin North America 4 27 Jun 2008 02:48
What does it do???xt question Dave O Yamaha Tech 14 12 Feb 2008 23:02
Gas question? gilghana1 Equipping the Overland Vehicle 4 29 Oct 2007 20:15
Here's a question for you!!! Chris1200 Yamaha Tech 8 23 Aug 2007 08:12
02 gsa abs question wyomex BMW Tech 3 7 Aug 2006 03:30

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 23:50.