Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Kawasaki Tech
Kawasaki Tech Kawasaki Tech Forum - For Questions specific and of interest to Kawasaki riders only.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 14 Jun 2009
Registered Users
Veteran HUBBer
 
Join Date: Oct 2005
Location: the haque, the Netherlands
Posts: 127
Mayor technical mystery


I have a technical problem which I can’t seen to figure out. I hope someone here has the answer.

The bike:

A KLE 500, build in 2001. Which has run about 50.000 kilometres. Every year I change the oil, re lube the filter, check and adjust the valve clearance and put in new sparks.
About a year ago I have driven it from Holland to Cape Town without any problem.

The problem:

The bike has been standing idle for two months (outside but under a roof) and when I to it for a ride it felt as if it lacked about 10 to 20 percent of its power. I put that down to the fact it had been standing outside so long and maybe some moisture had gotten in. I finished my ride and didn’t really think about it anymore. Two weeks ago I went for another ride. Again it felt as if it lackt about 10/20 percent of its power and every now and then it just didn’t want to speed up. Not every time I increased speed but every now and then it just seem to lose about 40/50 percent power. It stuttered just as if it was running out of fuel (an yes I did check the fuel tank, it had enough left)

So I thought because it behaved as it it was running out of fuel maybe the fuel filter was clogged up. So I replaced it with a new one, drained al the (two month old) fuel, because maybe it was deteriorated. Checked the spark plug cables, they were ok. Filled up with new fuel. Put some valvoline carburettor cleaning stuff in the fuel. I an a bit sceptic about stuff like that but my dealer insisted it would word. And went for a ride.

The problem had seemed to have gone away. The bike worked fine. I tried it on the highway. Doing 80 tot 120 sprints in high and law gear. I thought if it was I fuel quality or quantity problem it would show op then. But the bike worked fine, so I went home again. But than when I was doing 50 on a country road it again lost about 50 percent of its power. I stopped it, killed the engine, started again and it worked fine again.

So what the *&^% is the problem? I have no idea. I cant, reproduce it, it seems to come and go. Next week I’ll put in new sparks but I don’t really think that is the solution. The fault finding page of the manual didn’t help my either.

Anyone any idea?
Reply With Quote
  #2  
Old 14 Jun 2009
Registered Users
Veteran HUBBer
 
Join Date: Apr 2006
Location: Tallinn, Estonia
Posts: 1,048
Only basic suggestions:

Have you checked the air filter and made sure that a field mouse has not decided to make a nest in there? (no joke: it has happened!)

Have you done a compression check?

Does it sound like the bike is running on a single cylinder when it looses power? It could be that one cyclinder is not firing: an ignition coil one the way to failure, perhaps?

It is also worth checking the valve clearances, although this would be a constant, not intermittent problem... and I would also clean the carburretor internals, if I were you. You might have something blocking the main jets, or moisture in the reservoir, or a split diaphragm.

Good luck: I know how annoying these issues can be.
__________________
Adventure: it's an experience, not a style!
(so ride what you like, but ride it somewhere new!)
Reply With Quote
  #3  
Old 14 Jun 2009
pottsy's Avatar
Gold Member
Veteran HUBBer
 
Join Date: May 2007
Location: london, uk.
Posts: 360
When the bike seems to lose power, pull over and carefully touch the exhaust downpipe from each of the cylinders - if one is cooler than the other then you can determine which is not firing. If all ok then i'd look toward the coils, and if no problem there then check the air-intake for the field-mice/hamsters/gerbils etc (i once had an intermittent blockage here with a rag in the airbox intake, so it certainly does happen...).
Reply With Quote
  #4  
Old 15 Jun 2009
farqhuar's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Mar 2008
Location: Oztralia
Posts: 646
Did you check the fuel bowls in the carbies? I'd say there is a god chance they are half full of water and/or dirt.

Garry from Oz.
__________________
Garry from Oz - powered by Burgman
Reply With Quote
  #5  
Old 15 Jun 2009
Registered Users
Veteran HUBBer
 
Join Date: Oct 2005
Location: the haque, the Netherlands
Posts: 127
thanks guys, i hope its the gerbil thing. ontherwhise i'll do the coils and the carburrators.

wharthog, how do i do a compresion test and what would it tell me?
Reply With Quote
  #6  
Old 15 Jun 2009
Registered Users
Veteran HUBBer
 
Join Date: Apr 2006
Location: Tallinn, Estonia
Posts: 1,048
Quote:
Originally Posted by Luuk View Post
thanks guys, i hope its the gerbil thing. ontherwhise i'll do the coils and the carburrators.

wharthog, how do i do a compresion test and what would it tell me?
A compression test requires a compression gauge like this one:



It allows you to see if a cylinder has a healthy level of compression. Compression is the only thing that makes you bike go fowards. Without it everything else can work and your bike will still not run. It can indicate piston ring weat, valve seat wear, etc. I would not say it is essential to finding your problem, but if you did one and noticed that one or both cylinders were down on the compression, it would warn you of future problems and maybe explain why your bike is more likely to loose power.

Have a look here.
__________________
Adventure: it's an experience, not a style!
(so ride what you like, but ride it somewhere new!)
Reply With Quote
  #7  
Old 15 Jun 2009
Registered Users
HUBB regular
 
Join Date: Jun 2008
Location: NSW, Australia
Posts: 62
Check the tank breather - if it has a blockage or wasps nest in it, it will create a vacuum over time and use; as soon as you stop the bike the vacuum will normalise and will allow you to continue until the vacuum is again created. Another thing that can happen is pinching the line when you incorrectly route it when replacing the tank.

Just a VERY common complaint with a VERY common solution.

Let me know what you find if its anything different.

Cheers
Ian
Reply With Quote
  #8  
Old 15 Jun 2009
Registered Users
Veteran HUBBer
 
Join Date: Aug 2008
Location: Ireland
Posts: 106
Quote:
Originally Posted by farqhuar View Post
Did you check the fuel bowls in the carbies? I'd say there is a god chance they are half full of water and/or dirt.

Garry from Oz.
Yeah, I got water in the carb of my F650 and it caused very erratic problems like the ones mentiones here. The little drain hole inside the fuel cap got blocked.
Reply With Quote
  #9  
Old 15 Jun 2009
Registered Users
Veteran HUBBer
 
Join Date: Oct 2005
Location: Tappan, NY USA
Posts: 158
If the gas cap is anything like the KLR gas cap then the little rubber valves might have gone bad. Have you tried riding it with the gas cap off or lose?>
__________________
John C.
Reply With Quote
  #10  
Old 4 Jul 2009
Registered Users
Veteran HUBBer
 
Join Date: Oct 2005
Location: the haque, the Netherlands
Posts: 127
Problem seems to bee solved. Thanks guys.

I checked the breather hoses, no kinks
I checked the air system. No mammals or other stuff inside.
I checked the sparks. Looked good.
Fuelfilter in the fuel tank. Clean
Tanks gap. Mmm breather holes might have been a bit clogged. So I soaked it in water for a day and the gently blowed it clean.
Carbs. Gave the screw a few turns and a stream of clean fuel leaked out. So no problem there, the other carb didn’t though. It dripped verry slowly so it must have been clogged. So I hooked up a hose and inhaled. Bloody hell fuel tastes horibele but after that it worked ok again. Could have been some water inside or some dirt which became lose and flushed out.

So the bike runes ok now . Thanks for the tips.
Reply With Quote
  #11  
Old 4 Jul 2009
farqhuar's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Mar 2008
Location: Oztralia
Posts: 646
Glad I could help Luuk. Seriously though, it's no good just emptying the crap out of the fuel bowls through the drain plug, because you won't get it all out.

Take the carbies off, and remove the fuuel bowls completely and give them a good clean. It's almost certian there will be more water or some grit, dirt and corrosion in there.

Unless you clean them out properly your problem will recur again.
__________________
Garry from Oz - powered by Burgman
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Mystery petrol leak mwr09 Yamaha Tech 3 5 Apr 2009 15:20
Mystery map. Where is this from? budapestbamako North Africa 20 4 Nov 2006 16:58
Mystery disease in Nepal jkrijt West and South Asia 1 31 Oct 2006 19:49
1VJ Kickstarting Mystery Bernard Yamaha Tech 1 7 Jun 2006 15:24

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 15:38.