Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Kawasaki Tech
Kawasaki Tech Kawasaki Tech Forum - For Questions specific and of interest to Kawasaki riders only.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 16 Feb 2012
Registered Users
HUBB regular
 
Join Date: Jan 2009
Location: kent
Posts: 74
kle500 starting problems

hi.
i have a kle500 which will occasionally have trouble starting and just turn over and turn over but after being left for a minute or two tends to start. it is getting more common i think. there was a problem with the starter relay i think as it was just clicking at times and noit turning over. i have replaced this but now it sometimes just turns over and doesn't go.
any ideas anyone?
ive not done the valve clearances for a while or changed the plugs, could this be it?
any reasonably sensible suggestions would be appreciated.
regards.
nathan.
Reply With Quote
  #2  
Old 18 Feb 2012
Registered Users
New on the HUBB
 
Join Date: Mar 2011
Location: Poland
Posts: 16
Spark plugs seem to be the best bet for the beginning.

It's also possible, that the fuel tank vacuum valve is leaking, and therefore flooding the carbs, which may flood the engine when starting.

Try to start without choke, if it will start this way better than with choke, it will tell you it's flooded.
Reply With Quote
  #3  
Old 19 Feb 2012
Registered Users
HUBB regular
 
Join Date: May 2011
Posts: 65
Check the choke cable its self, I had a similar problem after I had new handlebars fitted and it turned out the garage had not connected the choke back properly.
Reply With Quote
  #4  
Old 19 Feb 2012
Registered Users
HUBB regular
 
Join Date: Jan 2009
Location: kent
Posts: 74
i have changed the plugs and it hasn't fixed it yet. dont think its the choke as i have tried it without and with choke. no real smell of petrol and it still does it when hot after a run so not sure what it might be really. might try cleaning the carbs next unless anyone has any better suggestions? it doesnt try to start, not nearly catching or firing or anything. just turns over. then when it does go it just springs to life and runs smoothly.
any more suggestions?
and thanks for your ideas so far!
regards.
nathan.
Reply With Quote
  #5  
Old 20 Feb 2012
Registered Users
New on the HUBB
 
Join Date: Mar 2011
Location: Poland
Posts: 16
if it doesn't try to fire at all, then I would bet some electrical problem or again, flooded engine.
But if it is flooded, it would have to be a huge amount of fuel, and shouldn't happen on hot engine (spark plugs are so hot that the fuel would evaporate off them VERY fast). Anyways, it wouldn't hurt to take out the plugs after few cranking attempts and take a look if they are wet.

I'm not sure how the spark module recognizes the crankshaft position in this engine, but if it's some hall-type sensor, I would bet this is the source of problem, since these sensors tend to fail this way- sometimes they work, sometimes they don't, up to a moment, when they stop working at all.

Check FSM to see where's the CPS and what type is it. Unfortunately today I'm horribly busy so I can't do it for you.
Reply With Quote
  #6  
Old 20 Feb 2012
Registered Users
Veteran HUBBer
 
Join Date: Mar 2007
Location: UK
Posts: 4,343
[QUOTE=nath23;368105. no real smell of petrol [/QUOTE]

Quote:
Originally Posted by mendelmax View Post
if it doesn't try to fire at all, then I would bet some electrical problem or again, flooded engine.
Or fuel starvation, which is what you seem to be describing Nathan.
The vast majority of non-starting probs for bikes amount to lack of a spark or lack of fuel - mix them together and you get a big bang

I suggest you keep things simple before making more detailed, possibly expensive for parts, changes; there are loads of threads about bikes in general all over the web for difficult starting issues.
__________________
Dave
Reply With Quote
  #7  
Old 20 Feb 2012
Registered Users
New on the HUBB
 
Join Date: Mar 2011
Location: Poland
Posts: 16
Good point Walkabout, I haven't thought about asking if nath23 tried to start it with fuel valve set on "prime" to eliminate the eventuality of a faulty vacuum hose.

Also, if this doesn't help it would be a good idea to check if there is fuel in the carbs, but I find it unlikely that both carbs would be completely clogged. If at least one carb would be fine, it would start running. Rough but still.
Reply With Quote
  #8  
Old 26 Feb 2012
Registered Users
HUBB regular
 
Join Date: Jan 2009
Location: kent
Posts: 74
right.
so far i have had the carbs off and given them a clean (but couldn't get the little pilot jet? out as i didn't have the right screwdriver so will have to go back to that i guess) i have replaced plugs ht leads and plug caps and have cleaned the air filter for good measure.
it still has starting problems. it doesn't splutter or try to start at all just turns over and then one time a few tries later it will fire up and now runs pretty well.
it was spluttering when i would open the throttle when at speed but will have to take it for a run to work tomorrow to check this. if it will bloody start.
me pal seems to think this may well be the pilot jets so gonne get these out soon as me new screwdriver turns up.
i've not done the valve clearances yet but not sure if this could cause a problem like this or not.
i need it to go and make it to the weekend or it will be costing me loads to get to work so hoping it will fire up in the morning please!!!!
thanks everyone for your input. very much appreciated.
nathan.
Reply With Quote
  #9  
Old 27 Feb 2012
Registered Users
New on the HUBB
 
Join Date: Mar 2011
Location: Poland
Posts: 16
Typically, valve clearance tends to cause problems on hot engine first (hot valves are longer, therefore reducing clearance), then after burning the seats it causes problems even at startup, but you would notice it.

The pilot jet is the jet that supplies fuel mainly on low engine revs, so indeed, it's more important than main jet when it comes to starting, it's good idea to clean it.
Don't want to offend you by telling such obvious things, but "just in case"- remember to back it up the same amount of revs it was before after screwing in!
Reply With Quote
  #10  
Old 22 Apr 2012
Registered Users
HUBB regular
 
Join Date: Jan 2009
Location: kent
Posts: 74
resolution . . .

thanks everyone
it turned out to be the carbs needed cleaning pretty badly and mainly the pilot jets i think. it now starts ok. i also replaced the hd leads and the spark plugs but it was still failing to start so took the carbs off again once i had the right screwdriver to get the pilot jets out. it now starts fine. by the way mandelmax - the pilot jet is not the one which you have to screw out a certain number of turns. this is the timing screw i think? the pilot jets just screw in inside the carbs and i think are mainly for getting petrol through to start the bike. i took the little timing screws out too and gave them a clean for good measure.
just learning about all this but enjoying the process too.
thanks everyone for your help.
much appreciated.
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Rtw starting april 2012 gsrichie Travellers Seeking Travellers 6 6 Feb 2012 08:37
Shanghai to Europe, starting April/May 2012 kali Travellers Seeking Travellers 0 28 Nov 2011 09:17
Problems with DHL to Iran Brian and Tanja Middle East 2 26 Nov 2011 11:37
Problems in Peru tripete Ride Tales 2 8 Nov 2011 01:14

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 10:46.