Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > BMW Tech
BMW Tech BMW Tech Forum - For Questions specific and of interest to BMW riders only.
Photo by Daniel Rintz, Himba children, Namibia

The only impossible journey
is the one
you never begin

Photo by Daniel Rintz,
Himba children, Namibia



Like Tree6Likes

Reply
 
LinkBack Thread Tools Display Modes
  #1  
Old 24 Dec 2013
Registered Users
Veteran HUBBer
 
Join Date: Jul 2002
Location: Oxfordshire, UK
Posts: 173
TKC80 dangerous wear pattern

My front wheel has suddenly started to slide around on corners in a more than exciting manner (on an R100GSPD with standard forks and wheels).

Looking at the TKC80 on the front I can see why. The knobs of tread have worn in a very uneven pattern, with some down to less than 1 mm and others barely worn. There is no common direction in which the wear is lying. Knobs that are right next to each other are worn in different ways and different directions.

It looks as if the contact patch of the tyre has been dangerously reduced.

The tyre has done about 2000 miles. I usually expect at least 3000.

Anyone else had this happen?

I'll be switching to Karoo 3 now. I think they have more rigidity, which might help.
Reply With Quote
  #2  
Old 24 Dec 2013
Endurodude's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Aug 2010
Location: Middle England, UK
Posts: 457
I've never used the TKC due to the fast wear rate, but I had the exact same thing happen to a front Mitas E10 I used over the Summer. I had some VERY scary moments where the tyre steered itself! The worst time was on a motorway coming down a mountain!
Reply With Quote
  #3  
Old 24 Dec 2013
mollydog's Avatar
R.I.P.
Veteran HUBBer
 
Join Date: Aug 2003
Location: california
Posts: 3,822
An Odd one Dec. 24th, 14:15 hrs.

Some pics would really help with this one. Hard to describe uneven tire wear. PICS !!

I've used TKC's on two of my bikes (not BMW's) ... never have had the radical uneven wear you describe. The rears do wear fast on pavement, the fronts last 3 times as long.

The one in pic below is from my DR650 (about 390 lbs. fully fueled and loaded) About 1500 miles on this tire. It's wearing quite well, about 800 miles tarmac, 700 miles dirt. Wearing perfectly! (PS: I never balance my wheels)


TKC80 front at 1500 miles. (90/90-21)

I've seen TKC fronts wear badly on a RTW R100GS (and other bikes) ... Some of the R100's were ridden on almost ALL paved roads ... so center wear was quite pronounced but wear was fairly even, save the unworn knobs on the side of the tire, which were still in fair shape.

Really the WRONG tire for paved roads ... and can be dangerous on wet, greasy roads, especially if over inflated. (I've seen a couple R1150GS riders GO DOWN running TKC's in wet. Not good)

Tire pressures are important and a wobbly wheel could also cause funny wear patterns. But you should feel this when riding if out of alignment or wobbling at various speeds.

Maybe try a nice 50/50 tire if riding at least 50% tarmac? (Heidenau, Shinko,
Kenda, Mefo et al)
Reply With Quote
  #4  
Old 24 Dec 2013
*Touring Ted*'s Avatar
Contributing Member
Veteran HUBBer
 
Join Date: Jul 2005
Location: Wirral, England.
Posts: 5,654
Nothing new with these tyres... It comes from long stretches on tarmac. There is no need for TKC's unless you're going to hit the trails..

Hiendenau K60's are better... My front lasted 30,000 miles and was still legal... Crazy !!
__________________
Did some trips.
Rode some bikes.
Fix them for a living.
Can't say anymore.
Reply With Quote
  #5  
Old 25 Dec 2013
chris's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Jun 2000
Location: GOC
Posts: 3,326
Imho tkc80s are sh!te. I've experienced quite a few. Weird wear patterns, short life, huge expense compared to better rubber like the Heidenau k60 that is as aggressive/ useful off road as the Conti but doesn't have the "rugged adventure look".
Reply With Quote
  #6  
Old 25 Dec 2013
*Touring Ted*'s Avatar
Contributing Member
Veteran HUBBer
 
Join Date: Jul 2005
Location: Wirral, England.
Posts: 5,654
Quote:
Originally Posted by chris View Post
Imho tkc80s are sh!te. I've experienced quite a few. Weird wear patterns, short life, huge expense compared to better rubber like the Heidenau k60 that is as aggressive/ useful off road as the Conti but doesn't have the "rugged adventure look".
CHRIS.... HOW CAN YOU SAY THAT.....

They're BMW approved fitment

And BMW knows best...
__________________
Did some trips.
Rode some bikes.
Fix them for a living.
Can't say anymore.
Reply With Quote
  #7  
Old 25 Dec 2013
chris's Avatar
Registered Users
Veteran HUBBer
 
Join Date: Jun 2000
Location: GOC
Posts: 3,326
Quote:
Originally Posted by *Touring Ted* View Post
CHRIS.... HOW CAN YOU SAY THAT.....

They're BMW approved fitment

And BMW knows best...
In the spirit of goodwill to all men on this auspicious 25th December, I am unable to comment further on the topic of BMW approved anything.

Drinking Efes pilsner at Olympos near Kemer in Turkey instead.
Reply With Quote
  #8  
Old 25 Dec 2013
Registered Users
Veteran HUBBer
 
Join Date: Jul 2002
Location: Oxfordshire, UK
Posts: 173
I've been using TKC80s since 2008. They've been very good, although short-lived. On the R100GSPD they usually give excellent grip on the road. In deep sand or mud they are near to miraculous.

The reason I switched to TKC80 was that I had a Tourance front tyre disintegrate through to the carcass on a long trip, even though the rest of the tyre had plenty of tread depth. That was after using Tourance for many years. I noted at the time that Metzeler had switched production from Germany to Brazil.

Tyre quality does seem to vary considerably, even with the same type of tyre.
Reply With Quote
  #9  
Old 25 Dec 2013
Registered Users
Veteran HUBBer
 
Join Date: Jul 2002
Location: Oxfordshire, UK
Posts: 173
Back to the original issue: this pattern of wear is very odd, with tread knobs worn in a seemingly random pattern.

Can anyone suggest a cause other than stating that TKC80s are rubbish? (in my experience they are good).
Reply With Quote
  #10  
Old 25 Dec 2013
Registered Users
New on the HUBB
 
Join Date: Sep 2013
Posts: 1
Out of balance?
Reply With Quote
  #11  
Old 25 Dec 2013
*Touring Ted*'s Avatar
Contributing Member
Veteran HUBBer
 
Join Date: Jul 2005
Location: Wirral, England.
Posts: 5,654
Excuse the pun... But it's just the way they roll. In a rotation, only certain parts of the tyre contacts the tarmac. Its the fronts that tend to go weird... I wouldn't worry about it too much..

Sent from my XT1032 using Tapatalk
__________________
Did some trips.
Rode some bikes.
Fix them for a living.
Can't say anymore.
Reply With Quote
  #12  
Old 26 Dec 2013
Contributing Member
Veteran HUBBer
 
Join Date: Feb 2005
Location: Australia
Posts: 130
Greetings Roboyobo

I'm curious, are you able to post or put up a link to a photo of your worn tyre?

I have/had a pair of TKC80 on my R100GSPD and I didn't see any sign of the wear you describe , but then again I have just had to replace the front tyre down here in Ushuaia due to a split puncture that screwed the tyre.

What sort of roads were you riding and what tyre pressures were you running?

Regards

Ian J
__________________
Always have plan B, and maybe plan C
www.travelswithkitty.com
Reply With Quote
  #13  
Old 26 Dec 2013
Registered Users
Veteran HUBBer
 
Join Date: Dec 2010
Posts: 114
Most of the more dirt orientated tyres will do it on hard surfaces for long enough,recently took the Pirelli mt21 off front of my tenere that had every other block worn away,had ridden it back from Spain like it,just have to aware the steering can be a little odd..bit like the owner realy so not a major problem...
Reply With Quote
  #14  
Old 26 Dec 2013
Globetrotter's Avatar
Contributing Member
Veteran HUBBer
 
Join Date: Oct 2006
Location: Switzerland
Posts: 112
Tkc 80

It's the normal wear pattern for this tyre. I went through several TKC 80 on my trip around the world with my AT750. I tried with different air pressure, sometimes even changed the tyre direction on the rim in order for the knobblies not to wear evenly. Nothing really helped. If you stay offroad it won't happen...
In my opinion the TKC 80 are too expensive. There are alternatives out there which cost less and do the job.
See: Reifen Statistik
here some other proplem I encounterd with this tyre and it happened more than once:
http://flic.kr/p/iCEYrd
and
http://flic.kr/p/iCEYCW


Greets

Claudio
__________________
-Challenge your Limits-

Last edited by Globetrotter; 26 Dec 2013 at 22:24. Reason: Added Pictures
Reply With Quote
  #15  
Old 26 Dec 2013
Registered Users
Veteran HUBBer
 
Join Date: May 2008
Location: SW France
Posts: 304
I agree that it is the normal wear pattern in my experience. I've had a couple of sets on my R100GS and they have both done this to some extent. I notice they are noisy on very hot tarmac (air temp >35C) and have put some of this excessive wear down to that.

I've used Pirelli MT21 on other bikes and have seen similar wear but then these bikes have very effective single disc brakes (unlike the R100GS).
Reply With Quote
Reply


Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Uneven wear brake pads xtrock Yamaha Tech 5 11 Oct 2013 00:37
Looking for TKC80 in La Paz, Bolivia dcaussie Travellers' questions that don't fit anywhere else 1 20 Sep 2013 17:13
Sale Continental TKC80 front & rear XT600 U.K. jimmy46 TRAVEL Equipment for Sale / Wanted 2 26 Apr 2013 23:13
Do you think riding India is dangerous? I am dangerous. The movie Miquel-Silvestre Ride Tales 0 11 Jan 2012 12:35
Most dangerous roads in Africa? Ants BK sub-Saharan Africa 9 18 Dec 2011 10:02

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now
, and add your information if we didn't find you.

Next HU Eventscalendar

HU Event and other updates on the HUBB Forum "Traveller's Advisories" thread.
ALL Dates subject to change.

2024:

Add yourself to the Updates List for each event!

Questions about an event? Ask here

HUBBUK: info

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord travel protection is now available for ALL nationalities, and travel is covered on motorcycles of all sizes!


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Diaries of a compulsive traveller
by Graham Field
Book, eBook, Audiobook

"A compelling, honest, inspiring and entertaining writing style with a built-in feel-good factor" Get them NOW from the authors' website and Amazon.com, Amazon.ca, Amazon.co.uk.



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.




All times are GMT +1. The time now is 13:59.